Oldsmobile Diesel engine

From Wikipedia, the free encyclopedia
Oldsmobile Diesel engine
Badge of the Oldsmobile Diesel on a Buick
Overview
ManufacturerOldsmobile
Production1978–1985
Layout
ConfigurationV6
V8
Displacement
  • V6:
  • 262.55 cu in (4,302 cc)
  • V8:
  • 260.54 cu in (4,269 cc)
  • 350.06 cu in (5,736 cc)
Cylinder bore
  • 3+12 in (88.9 mm)[1]
  • 4.057 in (103.0 mm)[1]
Piston stroke3.385 in (86.0 mm)[1]
Cylinder block materialCast iron
Cylinder head materialCast iron
ValvetrainOverhead valve 2 valves x cyl.
Compression ratio22.5:1,[1] 21.6:1[1]
Combustion
Fuel systemIndirect injection
Fuel typeDiesel
Oil systemWet sump
Cooling systemWater-cooled
Output
Power output85–120 bhp (63–89 kW)
Torque output160–220 lb⋅ft (217–298 N⋅m)
Chronology
SuccessorDetroit Diesel V8 engine

The Oldsmobile Diesel engine is a series of V6 and V8 diesel engines produced by General Motors from 1978 to 1985. Their design was based on the Olds 350 gasoline engine architecture. A 350 cu in (5.7 L) V8 was introduced in 1978, followed by a 261 cu in (4.3 L) V8 only for the 1979 model year. In 1982, a 263 cu in (4.3 L) V6 became available for both front front-wheel drive and rear-wheel drive vehicles.

Sales peaked in 1981 at approximately 310,000 units, which represented 60% of the total U.S. passenger vehicle diesel market. This success was short-lived as the V8 version suffered severe reliability issues. Although GM carried out several redesigns, by the time the engine was trouble-free, the damage to its reputation had been done, and it was discontinued after the 1985 model year. The later design V6 diesel did not have the problems of the V8.

Very few engines had more impact on the American light diesel market than the Oldsmobile 350 V8.

Problems[edit]

One Oldsmobile engineer who had worked on the V8 diesel told his bosses not to release the hastily developed engine. Needing to meet upcoming CAFE standards, GM forced him into early retirement and released the engine nonetheless.[2]

Simultaneous problems with GM's new THM200 automatic transmission made the overall problem worse. The California Air Resources Board (CARB) had been unable to certify the diesel V8 for sale in the state in 1979 and early 1980 as the test cars issued to CARB broke down before the tests could be completed. Of the nine cars supplied to CARB, all suffered engine problems and seven had transmission failures.[2]

Myriad lawsuits were filed as several grassroots groups formed to try to get General Motors to acknowledge the issues.[2] In 1980 the Federal Trade Commission filed a complaint which included the diesel engine issues and the transmission troubles, as well as camshaft issues with gasoline V8s.[2] General Motors kept marketing the diesel to the fullest, with 19 of the 23 Oldsmobile models in 1981 being available with the 5.7 diesel.[3]

The sales and reliability woes were compounded by a decline in gas prices as well as fuel quality issues, including large volumes of diesel fuel containing water or foreign particles.[4]

A class action lawsuit eventually forced General Motors to pay up to 80 percent of the costs of new engines. A large number of cars simply had their broken diesels replaced with conventional gasoline engines. Used car price guides have always indicated much lower prices for diesel-engined cars and they remain undesirable in the collector's market.[5]

The Oldsmobile diesel's reputation for unreliability and anemic performance damaged the North American passenger diesel market for the next 30 years.[6][7]

Design and flaws[edit]

While designing the original 350 cu in diesel, Oldsmobile left the head bolt design and pattern unchanged to enable them to use the same tooling as for the gasoline engines, unlike a proper gasoline to diesel conversion.[8] This led to catastrophic head bolt failures as diesel engines have compression ratios that are as much as three times higher than a gasoline engine.[8]

In addition to the head bolt issues, General Motors also decided not to install a water separator in order to cut costs.[8] Low quality diesel fuel was a common problem at the time and most diesels were thus equipped to keep the injector pumps from corroding. Many owners tried to solve this by adding anhydrous alcohol, a common trick to deal with water in fuel, but this instead dissolved fuel pump seals and other parts.

The stretchy fuel-pump timing chain was a minor problem in light of the other issues. Poor dealer service training only made all the problems worse.[8]

General Motors also carried out several redesigns of the V8's heads, bolts, and various other parts, but by the time the engine was trouble-free the reputation damage had already been done. The upgraded engines, as built by model year 1981, were identified as "350 DX" on the block.[9]

The later 4.3-liter V6 engine, which arrived for the 1982 model year, did not have the same problems as the V8. The V6 has a denser bolt pattern and Oldsmobile's engineers were given more time to develop and test it.[8]

Discontinuation[edit]

While customer complaints started dropping off after 1981, sales did too: diesels sold 43 percent less in 1982.[2] The downward sales slide continued, not helped by stricter emissions standards - for the 1984 model year the diesel V8 was no longer offered in California for that very reason.[10]

General Motors had built a whole new plant for the V6 diesel, but sales thereof never broke 30,000 annually. Production ran at less than ten percent of capacity and much of the tooling had never even been unpacked by the time it was discontinued.[11]

In December 1984, General Motors announced the Oldsmobile Diesel engines would be discontinued during the 1985 model year.[5] GM continued to offer Isuzu's 4FB1 1.8-liter four cylinder diesel in the Chevrolet Chevette/Pontiac 1000, but after only 588 of these were sold in 1986, the company went on to abandon the diesel passenger car segment entirely for many decades.[12]

Although the engines were unreliable because of the head and problems with the ancillaries, the Oldsmobile diesels' strong blocks continue to see use in gasoline-powered race engines.[4][13]

V8 engines by RPO code[edit]

LF9[edit]

The LF9 is a 350 cu in (5.7 L) diesel V8 produced from 1978 to 1985. Earlier versions and those used in pickups (1978-1981) produced 120 hp (89 kW) at 3,600 rpm and 220 lb⋅ft (298 N⋅m) torque at 1,900 rpm, while later versions produced 105 hp (78 kW) and 205 lb⋅ft (278 N⋅m) torque. Maximum engine speed was listed as 4,200–4,400 rpm.

Applications:

LF7[edit]

The short-lived LF7 is a 260 cu in (4.3 L) V8 putting out 90 hp (67 kW) and 160 lb⋅ft (217 N⋅m) torque.

Applications:

V6 engines by RPO code[edit]

1983 V6 experimental at the RE Olds Transportation Museum

In 1982, GM introduced a 4.3-liter V6 for longitudinal and transverse applications. All versions of the engine were rated at 85 bhp (63 kW) at 3600 rpm and 165 lb⋅ft (224 N⋅m) at 1600 rpm.

LT6[edit]

The LT6 was produced from 1982 to 1984 and installed in rear-wheel drive vehicles.

Applications:

LT7[edit]

The LT7 is a transverse engine version produced from 1982 to 1985.

Applications:

LS2[edit]

The LS2 was produced only in 1985 and installed in front-wheel drive vehicles.

Applications:

References[edit]

  1. ^ a b c d e "Oldsmobile Diesel Technical Magazine". Retrieved 20 Dec 2013.
  2. ^ a b c d e Decourcy Hinds, Michael (1983-03-27). "The Saga of the G.M. Diesel: Lemons, Lawsuits and Soon an F.T.C. Decision". New York Times: 8.
  3. ^ Chevedden, John; Kowalke, Ron (2012). Standard Catalog of Oldsmobile 1897–1997. Iola, WI: Krause Publications. p. 156. ISBN 978-1-4402-3235-0.
  4. ^ a b Fish, Randy (2014-08-23). "Better Off Dead". Archived from the original on 2015-04-12.
  5. ^ a b Chevedden and Kowalke, p. 130
  6. ^ "What's Hot". Archived from the original on 16 February 2012. Retrieved 11 Jan 2014.
  7. ^ "Technical: Diesel Redux". Retrieved 11 Jan 2014.
  8. ^ a b c d e Wojdyla, Ben (2011-05-04). "The Top Automotive Engineering Failures: Oldsmobile Diesels". Popular Mechanics. Hearst Magazine Media, Inc. Archived from the original on 2016-06-12.
  9. ^ a b c Day, Lewin (2024-03-04). "Let's Look Back At Chevy's First Diesel Pickup, An Engineering Disaster Based On A Gas V8". The Autopian.
  10. ^ Chevedden and Kowalke, p. 168
  11. ^ Zoia, David (1985). "GM Ends Nine-Year Term as Diesel Engine Manufacturer". Ward's Automotive Yearbook 1985. 47. Detroit, MI: Ward's Communications, Inc: 37. ISBN 0910589005.{{cite journal}}: CS1 maint: ignored ISBN errors (link)
  12. ^ Stoddard, Haig (1987). "6-cyl Engines Increased Share in '86 at the Expense of V-8 Installations". Ward's Automotive Yearbook 1987. 49. Detroit, MI: Ward's Communications, Inc: 48. ISBN 0910589007.{{cite journal}}: CS1 maint: ignored ISBN errors (link)
  13. ^ Truett, Richard (2005-05-13). "Ghosts of Diesels Past: Failed cars from 20 years ago still haunt GM, U.S. market". Autoweek. Archived from the original on 2015-10-23.